Search
Type
Audience
Category
Issue
Last updated
Please note: using the search filters may not provide accurate search results for records prior to November 2021. When searching for older records, please ensure that you use the include archive checkbox.
Displaying 1 - 15 of 105 items.
Issue:
On certain side-by-side UTVs, the connection between the fuel pump assembly and the fuel tank could leak. If this happens, fuel could leak onto hot surfaces that are nearby.
Safety Risk:
Fuel that leaks onto a hot surface could cause a…
RecallAutomotive recall | 2023-03-16
Issue:
On a small number of vehicles, the alternator may have been manufactured incorrectly. As a result, a part inside the alternator could crack and separate while the engine is running.
Safety Risk:
Alternator parts that break or separate can…
RecallAutomotive recall | 2023-03-03
Issue:
On certain side-by-side UTVs, the fuel pump outlet connector could develop a fuel leak.
Safety Risk:
A fuel leak can create the risk of a fire.
Corrective Actions:
Polaris will notify owners by mail and instruct you to take your…
RecallAutomotive recall | 2023-02-24
Issue:
Operating your snowmobile with a low fuel level after long-term storage could create increased risk of an electrostatic discharge (spark) inside the fuel tank. If this happens, vapours may be ignited inside the fuel tank, and the tank could…
RecallAutomotive recall | 2023-02-22
Issue:
On certain snowmobiles equipped with a Patriot Boost engine, the primary (drive) clutch bolt could break. If this happens, pieces of the clutch could separate from the vehicle.
Safety Risk:
Clutch parts that separate from the snowmobile…
RecallAutomotive recall | 2023-02-15
Issue:
The safety section in the owner's manual supplied with certain ATVs was incorrectly printed with information regarding side-by-side models.
Safety Risk:
Incorrect safety information in an owner's manual could create an increased risk of…
RecallAutomotive recall | 2023-01-25
Issue:
On certain ATVs, the throttle lever stop could break. If this happens, the throttle could stick in the open position.
Note: This replaces recalls A-18-06 and A-20-01 (Transport Canada recalls 2018-194 and 2020-169). ATVs that were repaired…
RecallAutomotive recall | 2023-01-05
Issue:
Under certain riding conditions, the brake system could overheat and catch fire.
Safety Risk:
Overheated brakes can create a fire risk.
Corrective Actions:
Polaris advises to stop using your snowmobile immediately. Polaris will…
RecallAutomotive recall | 2022-12-12
Issue:
On certain ATVs, a wiring harness may not have been assembled properly. As a result, a wire to the voltage regulator could contact a brake line or the vehicle frame and cause a short circuit. This could also result in a loss of front brakes…
RecallAutomotive recall | 2022-12-09
Issue:
If fuel spills while filling your ATV, an electrostatic discharge (spark) outside the fuel tank could start a fire.
Safety Risk:
A spark near a fuel spill can create the risk of a fire.
Corrective Actions:
Polaris advises to stop…
RecallAutomotive recall | 2022-11-17
On certain ATVs, the right side panel heat shield can melt. In addition, for the 2015 Sportsman 1000 models, the exhaust springs can stretch and damage the exhaust seal, which can result in exhaust leaks. Both of these conditions could pose burn and fire…
RecallAutomotive recall | 2022-11-09
On certain ATVs, operated in sub-freezing temperatures, for repeated short-run periods of time, excess moisture may collect and freeze in the outlet port of the crankcase ventilation valve assembly. If this occurs, a restriction of crankcase ventilation…
RecallAutomotive recall | 2022-11-09
On certain ATVs, the front suspension steering knuckles may not have been manufactured to specifications. Oversized ball joint stem mounting holes and oversized pinch bolt through holes may cause a reduction in the clamp force required to retain the…
RecallAutomotive recall | 2022-11-09
Issue:
On certain side-by-side UTV's, the accelerator pedal may not return when it is released. This could cause the throttle to stick open.
Note: This recall replaces R-21-01 (Transport Canada Recall 2021-008). If your UTV was inspected as a part of…
RecallAutomotive recall | 2022-11-04
Issue:
On certain side-by-side UTVs, the clutch could fail under certain operating conditions. If this happens, debris and/or clutch components could be ejected from the clutch housing.
Safety Risk:
Debris or parts that are ejected from the…
RecallAutomotive recall | 2022-10-13